云南高品質防火閥廠家

1、 薄鋼板矩形風管的剛度不夠,表現形式：風管的大邊上下有不同程度的下沉，兩側面小邊稍向外凸出，有明顯的變形。云南防火閥對產生的原因分析：① 制作風管的鋼板厚度不符合施工及驗收規范的要求；② 咬口的形式選擇不當；③ 沒有按照《施工及驗收規范》要求，對于邊長≥630 mm或保溫風管≥800 mm，其管長在1 200mm以上，均應采取加固措施。2 、薄鋼板矩形風管扭曲、翹角,表現形式：風管表面不平；對角線不相等；相鄰表面互不垂直；兩相對表面不平行及兩管端平面不平行等。防火閥產生的原因分析：① 矩形板料下料后，未對四個角進行嚴格的角方測量；② 風管的大邊或小邊的兩個相對面的板料長度和寬度不相等；③ 風管的四個角處的咬口寬度不相等；④ 手工咬口合縫受力不均。

現階段是很多雞舍都配備了通風管，我是2013年開始用的通風管，在使用過程中，曾經出現過很多問題，現總結一下，歡迎拍磚交流。一，通風管的作用。1降低操作負壓。冬季沒安裝通風管的雞舍，使用小窗通風，尤其是跨度大的雞舍為了導風合理安全，使用高負壓通風。而使用通風管道，由于進風在管道內基本不擴散，低負壓下都是按照風管方向，依次從開口處出風。2位置高，出風均勻。進風雖然在管道內沒有預熱，但下落位置高，向下擴散時間就是預熱過程。3跟風機配合合理配置，在初始開啟風機階段，由于設計問題導致進風窗使用不安全，可以利用通風管過渡。

鑒于軸流風機有紊流區的性能特點，在選型和使用時，需要注意以下兩點：建議使用在空曠環境中,軸流風機的輸入功率隨系統靜壓的增大而增大，而在紊流區，輸入功率的增大幅度會更大。因此，軸流風機一般多應用在有較大空曠環境的場合下，可以使其工作在靜壓較低的環境下，降低功耗，保證穩定性和壽命。定期清理風道,當軸流風機應用在較為封閉的風道系統中時，長期運行后風道中的積灰、垃圾逐漸變多，會使風道內的靜壓逐漸增加，使得風機的運行工況點逐漸左移。這不僅會降低風機性能，更重要的是會增加軸流風機進入紊流區的風險。因此必須要定期清理風道，保證風機工況點不產生較大偏移。

一、火災自動報警系統:對消防火災報警控制器進行自檢功能檢查：對可測量相關參數進行查看和記錄，如回路電流等；公共場所煙感器、溫感器安裝檢查，與底座接觸是否良好，外觀是否潔凈完好；每次隨機抽取不低于5%的煙感或溫感，噴煙或加熱后查視報警是否正確；手動報警按鈕，檢查安裝是否牢固，有無破損及丟失；每次隨機抽取不低于5%的手動報警按鈕，進行模擬報警，測試報警功能是否正常；對樓層內各模塊箱進行外觀檢查，外接線是否固定良好；對聯動控制柜上的按鈕每次按10%的比例進行功能試驗，控制功能正常。對火災報警控制柜、聯動控制柜等進行清掃除塵。線路松動，應進行緊固。對自檢、消音、復位功能檢查，主電源與備用電源切換、報警檢查。二、應急照明及疏散指示燈每3個月進行一次備用電池亮燈（半個小時），使電池放電后再充電，延長電池壽命；檢查出口指示燈玻璃面板有無劃傷或破裂現象；出口指示燈電源指示燈是否亮，如不亮，應立即修理；檢查出口指示燈安裝是否牢固；針對檢查中發現的缺陷取下來進行修復，再裝回原位；燈箱外殼及面板擦抹干凈。

排煙防火閥在火災發生時起到重要的保護作用，因此其安全及耐高溫性能要好。那么大家對其還有哪些了解呢？下面就跟隨簡要了解下其主要功能及相關優勢吧。這款排煙防火閥輸入DC24V電信號，電磁鐵動作、閥門敏捷敞開；手動封閉，手動復位敞開；可輸出閥門開封閉信號及聯鎖操控信號；0°～90°范圍內手動調理葉片敞開度；（調理型）。其主要優勢有：1.漏風量低、氣密功能好；2.電動敞開耗費電流小；3.防腐功能強，運用壽命長；4.執行機構驅動靈敏，反應、聯鎖信號精確。

1.風管程度安裝，邊長尺寸小于等于400mm，間距不應大于4m；大于400mm，不應大于3m；對于薄鋼板法蘭的風管，其支、吊架間距不應大于3m。2.風管垂直安裝，間距不應大于4m，單根直管至少應有2個固定點。3.支、吊架不宜設置在風口、閥門、檢討門及自控機構處，離風口或插接管的距離不宜小于200mm。4.當程度懸吊的主、干風管長度超過20m時，應設置防止擺動固定點，每個系統不應少于1個。5.防火閥直徑或長邊尺寸大于等于630mm時，宜設獨立支、吊架。6.帶高效過濾器的送風口，應采取可分離調節高度的吊桿。金屬風管的加固：矩形風管邊長大于630mm、保溫風管邊長大于800mm，并且管段長度大于1250mm或低壓風管單邊平面積大于1.2m2、中、高壓風管大于1.0m2中，均應采用加固辦法。角鋼、加固筋的加固，其高度應小于或等于風管的寬度。角鋼、加固筋與風管鉚接的間隔應均勻，不應大于220mm。.對于凈化空調系統，不應在風管內設加固框及加固筋。