渝中推薦天園地方管廠家

通風管道安裝程序：（1）風管組裝：當風管較短時，可一次在地面組裝而成，當風管較長時，可視安裝場地的情況，在地面分段組裝。組裝時應盡量調整風道的中心度和水平度，避免風管扭曲或上下起波，左右擺龍，每段風道不宜超過10m.組裝時，墊片應墊平，法蘭螺栓應均勻擰緊，螺母帽均朝向同一方向。（2）風管就位：風管就位前應檢查全部支架的水乎度和標高、檢查支架的牢固程度，風管就位可采用直接和吊具兩種方法。對風管斷面較小，又位置較低的可采用人工就位方法，只需搭設簡易腳手架即可。當風管斷面較大且管段較長時，可采用滑輪、倒鏈、大繩等方法吊裝。世紀星介紹為了便于風道就位，一般多采用將風道吊在腳手架上，然后再將其抬放在風道支架上的方法。腳手架應沿其風道長度方向搭設，高度和位置應適合施工操作，吊裝順序應先干管后支、立管，吊起時，吊點應牢固，兩吊點應均勻受力。垂直風管可采用人工和大繩輔助就位。調整風管保證垂直度要求。（3）風道調直：就位在支架上的風道，應撥正位置，調整風道橫平豎直，然后再按圖集要求固定。

常用的消防排煙風機的結構型式有內冷卻電風葉輪的型式、吸入冷卻電機氣流的型式、前導加動葉型式的低速吸入冷卻風的消防排煙風機等，它們的特點和效果有所不同。 3.1內冷卻電風葉輪的型式,這種排煙風機主流道的煙氣溫度高可達到280℃，煙氣裝在電機上的葉輪輸送，再電機原來裝設冷卻葉輪的地方，重新設計了用于冷卻電機的風扇，與機匣上開的進風口和出風口相連，并通過電機與風機輪組成的簡通道冷卻電機。此型式的電機冷卻通道可以保證在主流通道的溫度達到300℃時，機殼的溫度可以保持在130℃左右，在此環境溫度下，采用一般的絕緣等級的電機就可以達到效果，沒有必要采用高溫的絕緣電機，從而可以大大的降低風機的制作成本。這種型式的軸流消防電機的設計，國家鑒定已經下批，已經投入到生產當中，并且獲得了良好的經濟收益，目前是在進一步的研發和改造當中，從而能更好的提高工作效率，降低制造成本。

一、風管及部件安裝的有關規定1.風管安裝的強制規定,當風管穿過需要封閉的防火、防爆墻體或樓板時，應設預埋管或防護套管。套管鋼板厚度不應小于1.6mm，風管與防護套管之間應用不燃且對人體無害的柔性材料封堵，風道應安裝設防火閥。風管內嚴禁各種管道、電線敷設及穿越；輸送含有易燃易爆氣體或安裝在易燃易爆環境的風管系統，應有良好的接地，通過生活區、生產房間時必須嚴密，不得設接口；推薦天園地方管室外主管的固定拉索嚴禁拉在避雷針或避雷網上。輸送溫度高于80℃的空氣的風管，應按設計要求采取防護措施。2.風管安裝的一般規定風管安裝宜在建筑圍護結構施工完畢、場所清理后進行。凈化空調風管應在安裝部位地面做好，墻面抹灰工序完畢，室內無飛塵或有防塵措施后進行。渝中天園地方管安裝風管前應清除管內外雜物，并做好清潔和保護工作，風管安裝的位置、標高和走向等應符合設計要求，現場風管接口的配置不得縮小有效截面。

消防排煙風機風量與送風機風量計算方法是根據建筑面積來確定的，每個防煙分區都需要獨立計算其排煙量，當排煙風機擔負一個防煙分區的時候可按平方米面積不小于60m3／h計算，擔負多個防煙分區則按平方米面積不小于120m3／h計算。送風量按排煙量的50%計算。每個防煙分區不應大于500平方。常見的消防防排煙系統中，排煙量一般根據大防煙分區面積500*120等于60000立方每小時計算，在設計排煙量的時候要注意漏風量，一般可按小漏風量10%計算。例如：當建筑面積為1000平方時，需要設置兩個防煙分區，每個防煙分區的大面積為500平方，排煙量是500*1203／h=600003／h，再加上小漏風量10%為60003／h，總排煙量應為660003／h，其中送風量為排煙量的50%應為330003／h。

在空調送風系統中，空調送風機送出的風必須通過主干管分配到支管中；在排煙系統中，煙氣由支管到主干管后，進入排煙風機排出。當建筑物內發生火災時，在通風、空調系統中，為了防止火勢通過送風系統蔓延，當送風系統中氣體溫度達到70℃時，防火閥機構上熔斷器動作，閥門亦迅速關閥，切斷煙氣與火勢沿風管蔓延的通路。同樣，在排煙系統中，發生火災時，排煙閥開啟，進行排煙，為了截斷高溫煙氣在排煙管路中流動，防止火勢蔓延到另一防火分區，當排出的煙氣溫度達到280℃時，排煙防火閥、排煙口上熔斷器動作，閥門必須自動關閉，阻止排煙。由此可見，防火閥、排煙閥做到了該通則通，該斷則斷的隔煙阻火作用。

確保通風效果：高溫消防排煙風機的使用介質本身溫度相對較高，且自身的運轉也是會產生一定的溫度，若是將其放在密封環境中，那么很容易就會導致高溫現象發生，針對于這種情況在前期選擇安裝環境時就應該要多注意，好是能夠將其放在通風效果較好的環境中，通過對流運動來有效降低溫度，這是可以有效的防止高溫現象的發生。確保電流大小合適：消防排煙風機的使用還是要注意電流問題，是應該要防止電流過大現象發生，否則會讓在運行中會因為電流過大而產生較多的電阻，而這也是會導致高溫現象發生。因為高溫會直接影響著消防排煙風機的使用，因此在日常使用中就應該要采取措施來有效的防止高溫現象發生，且在高溫之后要采取措施來降溫，以確保安全。